华南理工大学学报(自然科学版) ›› 2007, Vol. 35 ›› Issue (3): 11-15,21.

• 机械工程 • 上一篇    下一篇

镁-稀土系ZEI0 镁合金板料的热拉深成形性能

王锦红1 夏伟1 周照耀1 张佩武1 郧建国2   

  1. 1.华南理工大学 机械工程学院,广东 广州 510640; 2. 韶关学院 机电系,广东 韶关 512005
  • 收稿日期:2006-06-09 出版日期:2007-03-25 发布日期:2007-03-25
  • 通信作者: 王锦红(1972),女,博士生,副教授,现任职于韶关学院机电系,主要从事金属精密成形及有限元数值模拟的研究 E-mail:wyangjh@163.com
  • 作者简介:王锦红(1972),女,博士生,副教授,现任职于韶关学院机电系,主要从事金属精密成形及有限元数值模拟的研究
  • 基金资助:

    广东省自然科学基金资助项目(04300124)

Warm Deep Drawability of Mg-RE Series ZE10 Magnesium Alloy Sheet

Wang Jin-hongXia WeiZhou Zhao-yaoZhang Pei-wuYun Jian-guo2   

  1. 1. School of Mechanical Engineering , South China Univ. of Tech. , Guangzhou 510640 , Guangdong , China;2. Dept. of Mechanical and Electrical Engineering , Shaoguan Univ. , Shaoguan 512005 , Guangdong , China
  • Received:2006-06-09 Online:2007-03-25 Published:2007-03-25
  • Contact: 王锦红(1972),女,博士生,副教授,现任职于韶关学院机电系,主要从事金属精密成形及有限元数值模拟的研究 E-mail:wyangjh@163.com
  • About author:王锦红(1972),女,博士生,副教授,现任职于韶关学院机电系,主要从事金属精密成形及有限元数值模拟的研究
  • Supported by:

    广东省自然科学基金资助项目(04300124)

摘要: 过对不同温度、冲头速率、压边方式、压边力以及润滑条件下板料的变形状态及冲压力一冲压行程曲线的研究,考察不同成形条件对ZElO娱合金板料成形性能的影响.在成形过程中,采用加热元件与热电偶连接的方式对凹模与冲头进行温度控制;通过对弹簧压下量的控制分别施加固定压边力与渐变压边力.结果表明,当凹模温度为250~300 ℃、冲头温度为(60±5) ℃、冲头速率为(20±5) mm/ min 时,采用浮动压边方式,压边力从2kN 逐渐增大到10kN ,并以80% 气缸油+20% 石墨作为润滑剂, ZE10娱合金板料具有较好的成形性能,其极限拉深比可达2.8.

关键词: ZE10镁合金, 热拉深, 极限拉深比, 起皱, 拉深性能

Abstract:

Based on the deforming status and punching load-displacement curves of ZElO magnesium alloy sheet ,the forming properties of ZE10 sheet were experimentally investigated. The experiments were carried out in different temperatures , punching velocities , blank-holding methods , blank-holding forces and lubricate oil. In the experi-ments, the temperatures of the die and the punch were controlled via the thermocouples connected to heating com-ponents, and the fixed and gradually changed blank-holding forces were exerted by controlling the compression de-gree of spring. The results show that , when the lower die and punch are respectively heated to 250~300℃and (60±5) ℃, the punching velocity is (20±5)mm/min,the blank-holding force increases from 2 to 10 kN,the mixture of 80% gas pump oil and 20% graphite is used as the lubricant , and the floating blank-holding method is adopted , ZE10 magnesium alloy sheet exhibits preferable forming properties with a limit drawing ratio of 2. 8.

Key words: ZE10 magnesium alloy, deep drawing, limited drawing ratio, wrinkling, drawability